-
Viscous Fingering Instability of Complex Fluids in a Tapered Geometry
Authors:
Alban Pouplard,
Peichun Amy Tsai
Abstract:
Viscous fingering (VF) is an interfacial instability that occurs in a narrow confinement or porous medium when a less-viscous fluid pushes a more viscous one, producing finger-like patterns. Controlling the VF instability is essential to enhance the efficiency of various technological applications. However, the control of VF instability has been challenging and so far focused on simple Newtonian f…
▽ More
Viscous fingering (VF) is an interfacial instability that occurs in a narrow confinement or porous medium when a less-viscous fluid pushes a more viscous one, producing finger-like patterns. Controlling the VF instability is essential to enhance the efficiency of various technological applications. However, the control of VF instability has been challenging and so far focused on simple Newtonian fluids of constant viscosity. Here, we extend to complex yield-stress fluids and examine the controlling feasibility by carrying out a linear stability analysis using a radial cell with a converging gap gradient. We avoid making the major assumption of a small Bingham number, Bn << 1, i.e., a negligible ratio of the yield to shear stress, and instead provide a new stability criterion predicting apparent complex VF. This criterion depends on not only the complex fluid's rheology, interfacial tension, and contact angle to the wetting wall, but also the gap gradient, the radius, gap-thickness, and velocity at the fluid-fluid interface. Finally, we compare this theoretical criterion to our experimental data with nitrogen pushing a complex yield-stress fluid in a taper and find good agreement.
△ Less
Submitted 16 May, 2022;
originally announced May 2022.
-
Control of Viscous Fingering Instability for Complex Yield-Stress Fluids using a Tapered Cell
Authors:
Alban Pouplard,
Peichun Amy Tsai
Abstract:
Being a major limiting factor for the efficiency of various technologies, such as Enhanced Oil Recovery, the viscous fingering (or Saffman--Taylor) instability has been extensively studied, especially for simple Newtonian fluids. Here, we experimentally and theoretically demonstrate a vital control of inhibiting the viscous fingering instability for complex (yield-stress) fluids to generate a comp…
▽ More
Being a major limiting factor for the efficiency of various technologies, such as Enhanced Oil Recovery, the viscous fingering (or Saffman--Taylor) instability has been extensively studied, especially for simple Newtonian fluids. Here, we experimentally and theoretically demonstrate a vital control of inhibiting the viscous fingering instability for complex (yield-stress) fluids to generate a complete sweep with a flat interface. Using a rectangular tapered cell, we first experimentally show the feasibility of controlling the primary fingering instability of a complex yield-stress fluid when pushed by another less viscous one. We further develop a theoretical linear stability analysis generalized for complex fluids with a yield stress and a power-law form of viscosity to provide insights. With three complex solutions yielding different viscosity contrasts, we observe stable flat and unstable wavy interfaces depending on the gap gradient ($α$) and injection flow rate ($Q$). Finally, the comparison reveals an agreeable theoretical stability criterion capable of predicting stable vs. unstable displacements for yield-stress fluids under various $α$.
△ Less
Submitted 16 May, 2022;
originally announced May 2022.
-
Controlling Viscous Fingering Instabilities of Complex Fluids
Authors:
Alban Pouplard,
Peichun Amy Tsai
Abstract:
The process of one fluid pushing another is universally common while involving complex interfacial instabilities. Particularly, occurring in a myriad of natural and industrial processes, wavy fingering patterns frequently emerge when a less viscous fluid pushes another more viscous one, such as water invading oil, in a porous medium. Such finger-shaped interfaces producing partial displacement sig…
▽ More
The process of one fluid pushing another is universally common while involving complex interfacial instabilities. Particularly, occurring in a myriad of natural and industrial processes, wavy fingering patterns frequently emerge when a less viscous fluid pushes another more viscous one, such as water invading oil, in a porous medium. Such finger-shaped interfaces producing partial displacement significantly affect the efficiency of numerous applications, for example, chromatography, printing devices, coating flows, oil-well cementing, as well as large-scale technologies of groundwater and enhanced oil recovery (EOR). This classical viscous fingering instability is notoriously difficult to control because the two fluids' viscosity or mobility ratio is often fixed and yet the predominant drive of the instability. Although some strategies have been recently revealed for simple fluids of constant viscosity, the feasibility of controlling the fundamental viscous fingering instability for omnipresent complex fluids has not been established. Here, we demonstrate how to control a common complex fluid (of a power-law fluid with a yield-stress) using a narrow tapered cell theoretically and experimentally.
△ Less
Submitted 16 May, 2022;
originally announced May 2022.
-
Multiphase CO2 Dispersions in Microfluidics: Formation, Phases, and Mass Transfer
Authors:
Tsai-Hsing Martin Ho,
Dan Sameoto,
Peichun Amy Tsai
Abstract:
The dissolution and microfluidic mass transfer of carbon dioxide in water at high-pressure conditions are crucial for a myriad of technological applications, including microreactors, extractions, and carbon capture, utilization, and sequestration (CCUS) processes. In this experimental work, we use a high-pressure microfluidic method to elucidate the mass transfer process of CO2 in water at high pr…
▽ More
The dissolution and microfluidic mass transfer of carbon dioxide in water at high-pressure conditions are crucial for a myriad of technological applications, including microreactors, extractions, and carbon capture, utilization, and sequestration (CCUS) processes. In this experimental work, we use a high-pressure microfluidic method to elucidate the mass transfer process of CO2 in water at high pressure. An intriguing multiphase CO2 flow and dispersions are observed when operating at the pressure-temperature ($P$-$T$) condition close to the CO2 gas-liquid phase boundary ($P=6.5$ MPa and $T=23.5\pm 0.5~^{\circ}$C). We propose a series of strategies to unravel this complex multi-phase dynamics by calculating each phase's volume and mass change in a gas-liquid coexistent CO2 dispersion, estimating the possible CO2 concentration change in water, and comparing with the CO2 solubility data. Finally, we quantify the CO2 mass transfer by directly calculating the CO2 dissolution rate in water and estimating the volumetric mass transfer coefficient ($k_{L}a$). The results show that the mass transfer may be influenced by the specific area ($a$), CO2 concentration gradient in the water slug, and the traveling speed of a dispersion.
△ Less
Submitted 16 July, 2021;
originally announced July 2021.
-
Cavitation nuclei regeneration in water-particle suspension
Authors:
Adrien Bussonnière,
Qingxia Liu,
Peichun Amy Tsai
Abstract:
Bubble nucleation in water induced by boiling, gas supersaturation or cavitation usually originates from pre-existing gas cavities trapped into solid defects. Even though the destabilization of such gas pockets, called nuclei, has been extensively studied, little is known on the nuclei dynamic. Here, nuclei of water-particle suspensions are excited by acoustic cavitation, and their dynamic is inve…
▽ More
Bubble nucleation in water induced by boiling, gas supersaturation or cavitation usually originates from pre-existing gas cavities trapped into solid defects. Even though the destabilization of such gas pockets, called nuclei, has been extensively studied, little is known on the nuclei dynamic. Here, nuclei of water-particle suspensions are excited by acoustic cavitation, and their dynamic is investigated by monitoring the cavitation probability over several thousand pulses. A stable and reproducible cavitation probability emerges after a few thousand pulses and depends on particle concentration, hydrophobicity, and dissolved gas content. Our observations indicate that a stable nuclei distribution is reached at a later-time, different from previously reported nuclei depletion in early-time. This apparent paradox is elucidated by varying the excitation rate, where the cavitation activity increases with the repetition period, indicating that the nuclei depletion is balanced by spontaneous nucleation or growth of nuclei. A model of this self-supporting generation of nuclei suggests an origin from dissolved gas adsorption on surfaces. The method developed can be utilized to further understand the spontaneous formation and distribution of nano-sized bubbles on heterogeneous surfaces.
△ Less
Submitted 16 December, 2019;
originally announced December 2019.
-
Manipulation of Viscous Fingering in a Radially-Tapered Cell Geometry
Authors:
Gregoire Bongrand,
Peichun Amy Tsai
Abstract:
When a more mobile fluid displaces another immiscible one in a porous medium, viscous fingering propagates with a partial sweep, which hinders oil recovery and soil remedy. We experimentally investigate the feasibility of tuning such fingering propagation in a non-uniform narrow passage with a radial injection, which is widely used in various applications. We show that a radially converging cell c…
▽ More
When a more mobile fluid displaces another immiscible one in a porous medium, viscous fingering propagates with a partial sweep, which hinders oil recovery and soil remedy. We experimentally investigate the feasibility of tuning such fingering propagation in a non-uniform narrow passage with a radial injection, which is widely used in various applications. We show that a radially converging cell can suppress the common viscous fingering observed in a uniform passage, and a full sweep of the displaced fluid is then achieved. The injection flow rate, $Q$, can be further exploited to manipulate the viscous fingering instability. For a fixed gap gradient $α$, our experimental results show a full sweep at a small $Q$ but partial displacement with fingering at a sufficient $Q$. Finally, by varying $α$, we identify and characterize the variation of the critical threshold between stable and unstable displacements. Our experimental results reveal good agreement with theoretical predictions by a linear stability analysis.
△ Less
Submitted 1 June, 2018;
originally announced June 2018.
-
Dynamics of microvortices induced by ion concentration polarization
Authors:
Joeri de Valenca,
R. M. Wagterveld,
Rob G. H. Lammertink,
Peichun Amy Tsai
Abstract:
We investigate the coupled dynamics of the local hydrodynamics and global electric response of an electrodialysis system, which consists of an electrolyte solution adjacent to a charge selective membrane under electric forcing. Under a DC electric current, counterions transport through the charged membrane while the passage of co-ions is restricted, thereby developing ion concentration polarizatio…
▽ More
We investigate the coupled dynamics of the local hydrodynamics and global electric response of an electrodialysis system, which consists of an electrolyte solution adjacent to a charge selective membrane under electric forcing. Under a DC electric current, counterions transport through the charged membrane while the passage of co-ions is restricted, thereby developing ion concentration polarization (ICP) or gradients. At sufficiently large currents, simultaneous measurements of voltage drop and flow field reveal several distinct dynamic regimes. Initially, the electrodialysis system displays a steady Ohmic voltage difference ($ΔV_{ohm}$), followed by a constant voltage jump ($ΔV_c$). Immediately after this voltage increase, micro-vortices set in and grow both in size and speed with time. After this growth, the resultant voltage levels off around a fixed value. The average vortex size and speed stabilize as well, while the individual vortices become unsteady and dynamic. These quantitative results reveal that micro-vortices set in with an excess voltage drop (above $ΔV_{ohm} + ΔV_c$) and sustain an approximately constant electrical conductivity, destroying the initial ICP with significantly low viscous dissipation.
△ Less
Submitted 19 September, 2015;
originally announced September 2015.
